FJ40

Head Turning FJ40

This FJ 40 is in excellent condition. It has had a ground up restoration including a new 350 crate motor & rebuilt 700R4 transmission with overdrive each with less than 3000 miles on them. It has an OLD MAN EMU suspension with a 2 ½ lift as well as a custom built radiator & Holley fuel injection system. It includes a brand new WARN Winch that has never been used. THIS FJ40 HAS NO RUST, the rust repair was completed by Iron Pig Offroad in Fredericksburg, VA. Everything has been restored, replaced or upgraded. It has new paint inside and out the entire truck was disassembled painted, and then re-assembled with new seals and emblems. It also comes with both full and half doors painted to match and a soft top and bikini top. It has more than enough Horse Power to climb any mountain but it is pretty enough to just sit and look at. The following is an outline of the restoration work that was done. You can see from both the pictures and description below that this is a great opportunity to own a classic in perfect condition. It has a clear VA title and you are welcome to stop by my house here in Blacksburg, VA to see it. This can be a daily driver it cruises fine on the interstate at 70 mph. This FJ40 has been sitting in a garage next to a dehumidifier since the restoration. Winning Bidder must make Paypal $500 Deposit within 24 hours and a cashiers check for the balance within7 business days. Buyer is responsible for transportation of vehicle. Sold as is no warranty. (I have invoices from the restoration, two huge folders of them). I reserve the right to end this auction at any time as this vehicle is for sale locally as well.

Frame

Stripped down to bare component, sprayed with bedliner

Custom front bumper with Warn M8000 Winch and KC Lights

Power train

New 350 crate motor from Jegs

Rebuilt 700R4 Trans and torque converter, Hurst shifter

Overhauled Toyo transfer case replaced all seals & bearings

Overhauled frt. & rear axels replaced all seals & bearing

3.73 gears front and rear

Front and rear lockers (Lock right front and Detroit rear)

New Holley TBI 2BBL fuel injection

New water pump, fuel pump, alternator, starter, and belts

All components were cleaned and repainted

New complete exhaust system with Edelbrock intake, Hedman Ceramic Headers and flowmaster exhaust

Cooling

New custom made aluminum radiator and shroud from Griffin

Replaced all lines & hoses

Heater cores flushed & pressure tested

Front heater unit repaired & powder coated (no rear heater unit)

Brakes

This rig had a four wheel disk brake conversion before I purchased it, it works perfectly

Whole system rebuilt during restoration

Steering & Suspension

Added Toyota Minitruck Power Steering Conversion from Iron Pig Offroad

Tie rods replaced

All frt. end components replaced or checked, cleaned & refinished

OLD Man EMU Shocks and springs with a 2 ½ in lift

All bushings replaced

Professional front end alignment

Interior & Electrical

New Procar front bucket seats & rear front facing seat (Now the rear seat is actually useable)

Powder coated seat frames

Roll bar sand blasted & powder coated, with sound bar and dome light

New OEM dash pads

Floor coated in bed liner

All new Autometer gauges and warning lamps, all controls gauges work perfectly

New painless wiring throughout

Specter Off-Road Carpet, front and rear

New poly gas tank with new sending unit

Body & Exterior

Entire vehicle was gone through and rust repaired by Iron Pig Offroad

All nuts & bolts replaced, most are now stainless steel

All weather stripping and window seals replaced

All body bushings replaced

New OEM Rear bumpers

Brand new OEM plates, latches, & badges

Undercoating applied while a bare tub

All new lamps from Spector (turn signals, tail lamps etc.)

All paint work done by Wilson Body Works in Richmond

Colors are based on factory Toyota paint codes (freeborn red)

Comes with full and half doors (both painted to match)

Half doors were custom made from two OEM steel doors by Iron Pig Offroad

All chrome parts were re-chromed

Bestop full soft top and bikini top

Wheels & Tires

New Mickey Thompson wheels

New 33x16 BRG All-Terrains with spare

Stereo

Sony MP3/WMA CD receiver

Sony 2-way 2 in tweeters on roll cage

Sony 3-way 6.5 in sound bar

Sony 3-way 6x9 in boxes on wheel well

Marine antenna hidden on front windshield